Experimental Study on Influence Factors of Anti-Wind Erosion and Anti-Dust for Construction Debris Cemented by MICP

LIU Zhong; XIAO Shuiming; LIU Feifei; LONG Wenliang; ZHANG Minxia

doi:10.13204/j.gyjzG22070609

Volume 52 Issue 11

Nov. 2022

Turn off MathJax

Article Contents

Abstract

References

Article Navigation > INDUSTRIAL CONSTRUCTION > 2022 > 52(11): 71-78

LIU Zhong, XIAO Shuiming, LIU Feifei, LONG Wenliang, ZHANG Minxia. Experimental Study on Influence Factors of Anti-Wind Erosion and Anti-Dust for Construction Debris Cemented by MICP[J]. INDUSTRIAL CONSTRUCTION, 2022, 52(11): 71-78. doi: 10.13204/j.gyjzG22070609

Citation:

LIU Zhong, XIAO Shuiming, LIU Feifei, LONG Wenliang, ZHANG Minxia. Experimental Study on Influence Factors of Anti-Wind Erosion and Anti-Dust for Construction Debris Cemented by MICP[J]. INDUSTRIAL CONSTRUCTION, 2022, 52(11): 71-78. doi: 10.13204/j.gyjzG22070609

Citation:

LIU Zhong, XIAO Shuiming, LIU Feifei, LONG Wenliang, ZHANG Minxia. Experimental Study on Influence Factors of Anti-Wind Erosion and Anti-Dust for Construction Debris Cemented by MICP[J]. INDUSTRIAL CONSTRUCTION, 2022, 52(11): 71-78. doi: 10.13204/j.gyjzG22070609

PDF( 11456 KB)

Experimental Study on Influence Factors of Anti-Wind Erosion and Anti-Dust for Construction Debris Cemented by MICP

doi: 10.13204/j.gyjzG22070609

1. Shenzhen Municipal Engineering Corporation, Shenzhen 518000, China;
2. School of Civil Engineering, Henan Polytechnic University, Jiaozuo 454150, China

Received Date: 2022-07-06

Abstract

Abstract

In order to systematically study the effect of calcium sources, cementitious solution concentrations, bacteria liquid concentrations, temperatures and pH values of microbial cementitious liquids on the resistance capacity of fugitive dust and wind erosion of construction debris cemented by microbial induced calcite precipitation (MICP), single-factor orthogonal tests cemented construction debris by MICP and wind tunnel tests were conducted, assisted by SEM and XRD microscopic methods. The test results showed that using calcium chloride as a calcium source, the concentration of the cementitious solution was 0.5 mol/L, the concentration of the bacterial liquid (OD₆₀₀) was 4.0, the temperature was 20 to 40 ℃, and the resistance effect of wind erosion for construction debris cemented by MICP in the neutral or weakly alkaline environment was better. The maximum increments of the soluble salt content and the pH value in construction debris cemented by MICP were 0.92% and 0.20 respectively,and the method to cement construction debris by MICP was of the advantage of environmental friendliness.
- microbial induced calcite precipitation,
- construction debris,
- dust suppression,
- influence factor,
- microscopic mechanism

FullText(HTML)

References(23)

References

[1]	DOUGLAS W, DOCKERY C A P X. An association between air pollution and mortality in six U.S. cities[J]. The New England Journal of Medicine, 1993, 329(24):1753-1759.
[2]	PRYOR S C, SIMPSON R, GUISE-BAGLEY L, et al. Visibility and aerosol composition in the fraser valley during reveal[J]. Journal of the Air & Waste Management Association. 1997, 47(2):147-156.
[3]	田延振. 工地建筑扬尘对大气污染的影响及其防治对策[J]. 环境与发展, 2018, 30(11):69-72.
[4]	YAN W, HOEKMAN S. Dust suppression with glycerin from biodiesel production:a review[J]. Journal of Environmental Protection, 2012,3:218-224.
[5]	江召兵,张倩,杨峰,等. 施工工地扬尘治理工程技术概述[J]. 资源节约与环保, 2019(2):52-53.
[6]	薛丹,刘小彬. 深圳市裸土地扬尘污染治理成效与提升对策[J]. 环境科学导刊, 2019, 38(5):66-70.
[7]	NAEIMI M, CHU J. Comparison of conventional and bio-treated methods as dust suppressants[J]. Environmental Science and Pollution Research, 2017, 24(29):23341-23350.
[8]	TIAN K, WU Y, ZHANG H, et al. Increasing wind erosion resistance of aeolian sandy soil by microbially induced calcium carbonate precipitation[J]. Land Degradation & Development, 2018, 29(12):4271-4281.
[9]	ZHAN Q, QIAN C, YI H. Microbial-induced mineralization and cementation of fugitive dust and engineering application[J]. Construction and Building Materials, 2016, 121:437-444.
[10]	高玉峰,杨恩杰,何稼. 基于微生物诱导碳酸钙沉积的防风固沙试验研究[J]. 河南科学, 2019, 37(1):144-150.
[11]	BANG S C, MIN S, BAO S. Application of microbiologically induced soil stabilization technique for dust suppression[J]. International Journal of Geo-Engineering, 2011, 3(2):27-37.
[12]	MEYER F D,BANG S,MIN S,et al. Microbiologically-induced soil stabilization:application of sporosarcina pasteurii for fugitive dust control[C]//Geo-Frontiers Congress. 2011:4002-4011.
[13]	WANG Z, ZHANG N, DING J, et al. Experimental study on wind erosion resistance and strength of sands treated with microbial-induced calcium carbonate precipitation[J]. Advances in Materials Science and Engineering, 2018. DOI: 10.1155/2018/3463298.
[14]	OLIVEIRA P J V, FREITAS L D, CARMONA J O P S. Effect of soil type on the enzymatic calcium carbonate precipitation process used for soil improvement[J]. Journal of Materials in Civil Engineering,2017,29(4). DOI: 10.1061/(ASCE)MT.1943-5533.0001804.
[15]	明道贵,邱明喜,殷立静,等. 钙源对微生物固化风积沙效果影响的试验研究[J]. 人民黄河, 2020, 42(4):85-88 , 111.
[16]	中华人民共和国水利部. 土工试验方法标准:GB/T 50123-2019[S]. 北京:中国计划出版社, 2019.
[17]	SONG H, ZHANG K, PIAO S, et al. Spatial and temporal variations of spring dust emissions in northern China over the last 30 years[J]. Atmospheric Environment,2016,126. DOI: 10.1016/j.atmosenv.2015.11.052.
[18]	JIANG L, XIAO Y, ZHENG H, et al. Spatio-temporal variation of wind erosion in Inner Mongolia of China between 2001 and 2010[J]. China Geogiaphical Science, 2016,26(2):155-163.
[19]	王雅倩. 基于风洞实验的裸露农田土壤PM10和PM2.5起尘特征研究[D]. 天津:天津师范大学, 2019.
[20]	石俊汇,张明远,赵芳芳. 平原县风沙区的水土流失与防治对策[J]. 中国水土保持, 2012(2):61-62.
[21]	中华人民共和国国家质量监督检验检疫总局. 水质钙的测定EDTA滴定法:GB 7476-87[S]. 北京:中国标准出版社, 1987.
[22]	彭劼,温智力,刘志明,等. 微生物诱导碳酸钙沉积加固有机质黏土的试验研究[J]. 岩土工程学报, 2019, 41(4):733-740.
[23]	SOON N W, LEE L M, KHUN T C, et al. Factors affecting improvement in engineering properties of residual soil through microbial-induced calcite precipitation[J]. Journal of Geotechnical and Geoenvironmental Engineering, 2014, 140(5):1-11.

Relative Articles

[1]	SONG Shuxiang, ZHENG Chao, YANG Kun, FENG Deluan. Experimental Research on Curing Characteristics of Sludge with High-Salt- Content Leachate Solidified by Cement in Domestic Waste Landfills[J]. INDUSTRIAL CONSTRUCTION, 2025, 55(2): 206-215. doi: 10.3724/j.gyjzG22110711
[2]	DING Shijun, DING Mintao, MAN Yin, NIE Zhibao. Analysis on Effect Factors and Characteristics of Shear Properties for Interfaces Between Basalt and Concrete[J]. INDUSTRIAL CONSTRUCTION, 2023, 53(1): 194-200. doi: 10.13204/j.gyjzG22060607
[3]	ZHU Yizhong, LI Bijun, ZHANG Qianru, WANG Tao, YANG Qiannan. Research on Influencing Factors of Satisfaction with Transformation of Old Industrial Lands into Cultural and Creative Parks in Guangzhou[J]. INDUSTRIAL CONSTRUCTION, 2022, 52(3): 77-84. doi: 10.13204/j.gyjzG20112503
[4]	WANG Lei, WANG Bo, LIU Zhiqiang, CHANG Xinhao. Advances of Soil Cemented by Enzyme Induced Calcium Carbonate Precipitation[J]. INDUSTRIAL CONSTRUCTION, 2022, 52(11): 57-66. doi: 10.13204/j.gyjzG22061503
[5]	CHEN Hang-jie, HE Fei, WANG Xu, CHEN Ming-wei. Research on Influence of Roughness on Shear Characteristics of Interfaces Between Frozen Soil and Structures[J]. INDUSTRIAL CONSTRUCTION, 2022, 52(9): 186-192,213. doi: 10.13204/j.gyjzG22012005
[6]	LIAO Mingjin, AN Wen, TANG Hua, DENG Qin, YU Shangyang. STUDY ON CHARACTERISTICS OF UPLIFT-BEARING CAPACITY AND INFLUENCE FACTORS OF TUNNEL ANCHORAGE[J]. INDUSTRIAL CONSTRUCTION, 2021, 51(4): 139-147. doi: 10.13204/j.gyjzG19082020
[8]	Wei Demin, Guo Lei, Zhang Haiyan. ANALYSIS OF INFLUENCE FACTORS ON SEISMIC PERFORMANCE OF REINFORCED CONCRETE STAIRS[J]. INDUSTRIAL CONSTRUCTION, 2013, 43(10): 61-65,70. doi: 10.13204/j.gyjz201310014
[9]	Ding Chang, Liu Jiaping. CONNOTATION AND MODALITY EXPRESSION OF TRADITIONAL URBAN ARCHITECTURAL COLOR IN LHASA[J]. INDUSTRIAL CONSTRUCTION, 2012, 42(8): 45-48. doi: 10.13204/j.gyjz201208010
[10]	Shen Baohan, He Dexin, Sun Junping, Liu Zhenliang, Tian Zhongsheng. FACTORS AFFECTING THE VERTICALLY COMPRESSIVE BEARING CAPACITY OF DX PILES[J]. INDUSTRIAL CONSTRUCTION, 2008, 38(5): 32-38,4. doi: 10.13204/j.gyjz200805007
[11]	Wang Lei, Zhou Jian, Jia Mincai, Xiao Zhaoran. ANALYSIS OF EFFECT FACTORS ON BURIED PIPELINE DUE TO EXCAVATION OF TWO ADJACENT FOUNDATIONS[J]. INDUSTRIAL CONSTRUCTION, 2008, 38(10): 65-70. doi: 10.13204/j.gyjz20081017
[12]	He Mingsheng, Yao Qianfeng, Chen Guoxin, Huang Wei. RESEARCH ONMECHANICAL BEHAVIOR AND INFLUENCE FACTORS OF MULTI-RIBBED SLAB STRUCTURE UNDER AXIAL COMPRESSION[J]. INDUSTRIAL CONSTRUCTION, 2008, 38(1): 14-18. doi: 10.13204/j.gyjz200801004
[13]	Li Qing-fu, Zhang Peng. EXPERIMENT ON IMPERMEABILITY OF PLASTIC CONCRETE[J]. INDUSTRIAL CONSTRUCTION, 2007, 37(4): 48-51. doi: 10.13204/j.gyjz200704014
[14]	Li Jian-jun, Zhao Shu-de, Wang Tie-hang. RESEARCH ON THE PROPERTIES OF THE CEMENT-LOESS[J]. INDUSTRIAL CONSTRUCTION, 2006, 36(7): 25-28,40. doi: 10.13204/j.gyjz200607005
[15]	Liu Fuzhi, . A STUDY ON THE BUILDINGSc CAPACITY IN OLD AREA OF CITY[J]. INDUSTRIAL CONSTRUCTION, 2006, 36(9): 36-38.
[16]	Guo Zhongxian, Zhang Yanjun. STUDY ON BEARING MECHANISM AND CRITICAL LENGTH OF RAMMED SOIL-CEMENT PILE[J]. INDUSTRIAL CONSTRUCTION, 2006, 36(12): 56-59. doi: 10.13204/j.gyjz200612016
[17]	Zhou Hongbo. NUMERICAL SIMULATION OF THE RELATIONSHIP OF BEARING CAPACITY OF POST-GROUTING BORED PILE AND GROUTING PARAMETERS[J]. INDUSTRIAL CONSTRUCTION, 2005, 35(9): 60-63. doi: 10.13204/j.gyjz200509016
[18]	Peng Fuming, Yue Qingrui, Hao Jiping, Yang Yongxin. LOAD TRANSFER ANALYSIS OF STEEL STRUCTURES REPAIRED WITH FRP[J]. INDUSTRIAL CONSTRUCTION, 2005, 35(8): 26-30,109. doi: 10.13204/j.gyjz200508006
[19]	Yue Qingrui, Cao Jinsong, Yang Yongxin, Zhao Yan. NORMATIVE SPECIMEN OF CARBON FIBER REINFORCED POLYMER SHEETS FOR CHECKING PROPERTY[J]. INDUSTRIAL CONSTRUCTION, 2005, 35(8): 1-4. doi: 10.13204/j.gyjz200508001
[20]	Zhang Chunmei, Yin Yi, Zhou Yun. ANALYSIS OF FACTORS INFLUENCING AXIAL COMPRESSIVE BEARING CAPACITY OF CONCRETE-FILLED STEEL TUBE COLUMN[J]. INDUSTRIAL CONSTRUCTION, 2004, 34(10): 66-68. doi: 10.13204/j.gyjz200410020

Supplements(0)

Cited By

Cited by

Periodical cited type(8)

1.	胡其志，霍伟严，马强，陶高梁. 微生物固化纤维加筋黄土影响因素试验研究. 湖北工业大学学报. 2025(01): 87-92 .
2.	易文，杜撰文，黄盎峰，刘谭剑. 胶质芽孢杆菌改良煤矸石抗风蚀性能研究. 兰州交通大学学报. 2025(01): 1-9+38 .
3.	胡雯璐，刘鹏. 脲酶喷洒工艺对赤泥矿化胶结及抑尘效果试验. 林业工程学报. 2025(02): 173-179 .
4.	张敏霞，王亚涛，刘璐，牛双建，康俊亚，房燕飞. 微生物固化工程裸土抗风蚀扬尘性能试验研究. 河南理工大学学报(自然科学版). 2024(04): 169-176 .
5.	崔秀丽，李佳禧，谢佳旻，林军，庞书孟. 生物炭联合微生物矿化技术改善软土力学性能试验研究. 水利水电技术(中英文). 2024(07): 134-146 .
6.	林文彬，王彬，高玉朋，柯劲涛，曹生根，孔秋平. 海水环境下微生物诱导碳酸钙沉淀胶结散体状强风化花岗岩崩解试验研究. 工业建筑. 2024(09): 1-9 . 本站查看
7.	祝富豪，晋强，周满旭. 钢渣微粉对微生物固化风积沙强度影响的试验研究. 新疆农业大学学报. 2023(02): 153-158 .
8.	陈龙，刘鹏，胡雯璐，许程. 微生物固化拜耳法赤泥的耐久性研究. 林业工程学报. 2023(05): 160-166 .