硫酸盐环境下碳纤维增强复材片材拉伸性能试验研究

刘生纬; 赵建昌; 张家玮

doi:10.13204/j.gyjzG201908060007

硫酸盐环境下碳纤维增强复材片材拉伸性能试验研究

doi: 10.13204/j.gyjzG201908060007

兰州交通大学研究院, 兰州 730070

基金项目:

国家自然科学基金（51368035）；甘肃省住房和城乡建设厅科技攻关项目（JK2014-16）。

详细信息

作者简介:
刘生纬,男,1988年出生,博士。

通讯作者:
张家玮,zhangjd@mail.lzjtu.edu.cn。

计量
- 文章访问数: 74
- HTML全文浏览量: 11
- PDF下载量: 3
- 被引次数: 0
出版历程
- 收稿日期: 2019-08-06

EXPERIMENTAL RESEARCH ON TENSILE PROPERTIES OF CFRP SHEETS IN SULFATE ENVIRONMENT

Research Institute, Lanzhou Jiaotong University, Lanzhou 730070, China

摘要

摘要: 为了研究硫酸盐腐蚀对碳纤维增强复合材料（CFRP）片材力学性能的影响，对11组77个CFRP试件进行单向受拉试验。试验着重考虑硫酸盐浓度和腐蚀时间对CFRP片材受拉破坏特征及抗拉强度、弹性模量、伸长率等力学性能的影响。结果表明：1）硫酸盐干湿循环作用对CFRP片材的破坏过程及破坏特征几乎没有影响；2）腐蚀前后CFRP片材的应力-应变关系均为线弹性；3） CFRP片材抗拉强度和伸长率随着腐蚀时间的增加逐渐下降，并且硫酸盐浓度越高下降越显著；4）硫酸盐干湿循环作用对CFRP片材的弹性模量影响很小。通过对试验数据的分析，提出了考虑腐蚀时间的抗拉强度计算方法，通过计算值与试验值的对比分析可知，该计算方法能很好地反映硫酸盐干湿循环作用下CFRP片材抗拉强度的退化规律。
- 硫酸盐 /
- 干湿循环 /
- 碳纤维增强复合材料 /
- 拉伸性能
Abstract: In order to study the effect of sulfate corrosion on the mechanical properties of CFRP (carbon fiber reinforced polymer) sheets, unidirectional tensile tests were carried out on 11 groups of 77 CFRP specimens. The effects of sulfate concentration and corrosion time on tensile failure characteristics, tensile strength, modulus of elasticity and elongation of CFRP sheets were considered. The results showed that: 1) Sulfate dry-wet circulation has little effect on the failure process and failure characteristics of CFRP sheet; 2) The stress-strain relationship of CFRP sheets before and after corrosion was linear elasticity; 3) The tensile strength and elongation of CFRP sheets decreased with the increase of corrosion time, and the more significant the sulfate concentration was higher; 4) Sulfate dry and wet cycle has little effect on the elastic modulus of CFRP sheet. Based on the analysis of the test data, the calculation method of tensile strength considering corrosion time was proposed. The calculated method could reflect the degradation law of tensile strength of CFRP sheet under the action of sulfate dry and wet cycle by comparing the calculated value with the experimental value.
- sulfate /
- dry-wet circulation /
- carbon fiber reinforced polymer /
- tensile properties

HTML全文

参考文献(15)

曹文海,施嘉伟. 黏结树脂对复材-混凝土界面疲劳性能影响的试验研究[J]. 工业建筑, 2019, 49(9):28-35.

黄辉,何箐,贾彬,等. 碳纤维复材-钢复合板材单向拉伸力学性能试验研究[J]. 工业建筑, 2019, 49(3):6-11.

叶列平, 冯鹏. FRP在工程结构中的应用与发展[J]. 土木工程学报, 2006, 39(3):24-34.

于峰,牛荻涛.长细比对FRP约束混凝土柱承载力的影响[J]. 土木工程学报, 2008, 41(6):40-44.

李杉. 环境与荷载共同作用下FRP加固混凝土耐久性[D]. 大连:大连理工大学, 2009.

TENG J G, CAO S Y, LAM L. Behavior of GFRP Strengthened RC Cantilever Slabs[J]. Constr Build Mater,2001,15(7):339-349.

ARMSTRONG K B. Effect of Absorbed Water in CFRP Composites on Adhesive Bonding[J].Int. J. Adhesion and Adhesives, 1996, 16(1):21-28.

WU L X, HOA S V, MINH-TAN T T. Effects of Water on the Curing and Properties of Epoxy Adhesive Used for Bonding FRP Composite Sheet to Concrete[J]. Journal of Applied Polymer Science,2004,92:2261-2268.

SELZER R,FRIEDRICH K. Mechanical Properties and Failure Behaviour of Carbon Fibre-Reinforced Polymer Composites Under the Influence of Moisture[J]. Composites Part A,1997, 28:595-604.

HULATT J, ROLLAWAY L, THORNE A.Preliminary Investigations on the Environmental Effects on New Heavyweight Fabrics for Use in Civil Engineering[J]. Composites:Part B, 2002,33:407-414

全国纤维增强塑料标准化技术委员会秘书处.纤维增强塑料(玻璃钢)标准汇编[M]. 北京:中国标准出版社,1998.

中华人民共和国住房和城乡建设部.普通混凝土长期性能和耐久性能试验方法标准:GB/T 50082-2009[S].北京:中国建筑工业出版社,2009.

WU Z S, IWASHITA K, YAGASHIRO S, et al. Temperature Effect on Bonding and Debonding Behavior Between FRP Sheets and Concrete[J].Journal of the Society of Materials Science Japan, 2005, 54(5):474-475.

TOMMASO A D, NEUBAUER U, PANTUSO A, et al. Behavior of Adhesively Bonded Concrete-CFRP Joints at Low and High Temperatures[J]. Mechanics of Composite Materials, 2001, 37(4):327-332.

SILVA M A, BISCAIA H. Degradation of Boned Between FRP and RC Beams[J]. Composite Structures, 2008, 85(2):164-171.

施引文献

资源附件(0)

访问统计